Stuffed Italian Sausage Smoke Bomb: The Ultimate Meatloaf Recipe

Steps

1. 1Prep. Make my Marvelous Marinara Sauce. You can do this a day or two in advance.
2. 2Fire up. Set up a 2-zone fire if you are using a grill. Heat the grill so the medium zone is about 350°F (167°C). Go back indoors and lay a strip of aluminum foil at least 12" x 16" (30 cm x 41 cm) on a work surface.
3. 3Make the sausage roll. If the sausage is in links, slit the casings from end to end with a knife, peel it off, and discard it. Then form the sausage into a ball. Lay the ball in the center of the foil and flatten it so it is at least 1" (25 mm) smaller than the foil on 3 sides and about 1/2" (1.3 cm) thick.
4. 4Chop the peppers and onions, and cube the mozzarella (shredded also works). In a bowl, mix the peppers, onion, oregano, salt, and pepper. Place a single layer of stuffing on the sausage up to about 1" (25 mm) of the edge of the sausage. Distribute the cheese on the stuffing. Don't try to cram a lot in. Depending on the size of the peppers and onions, you probably will need less than half in the stuffing. Set the rest of the vegetables aside.
5. 5Lift one edge of the foil and roll the sausage around the stuffing, making a loaf. Squeeze the foil at the top fusing the two edges. Pull back the foil and form the loaf until it is cylindrical and snug, sealing the seam and ends with your fingers. Pat it into an an even thickness. Lay the bacon over the top of the loaf with each strip not quite touching. Tuck any loose ends under the loaf.
6. 6Place your wood chips on the heat source and place the loaf, still in the center of the foil, on the cooker, seam side down in the medium heat zone. Cook for 45 to 60 minutes until it hits an internal temp of 160°F (71°C). The bacon should be just right.
7. 7While it is cooking, heat a frying pan over medium high heat, add the olive oil, and cook the remaining bell peppers and onions until soft. When you are ready to serve, warm the marinara sauce in a saucepan or the microwave.
8. 8Just before the meat loaf is done, start 1 quart (1 L) of water boiling in a 2 quart (1.9 L) pot. Add 2-3 pinches of salt. Then the pasta. Cook according to the instructions on the bag or box. Just before it is done, bring in the meatloaf.
9. 9Slice the loaf between the bacon strips. Drain the pasta, put it on the plates, top with the marinara sauce, then the cooked peppers and onions, then the sliced meatloaf.